Macdon 9250 SP User Manual Page 139
- Page / 160
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Form # 46584 Issue 11/06 Web Rev_01
137
ASSEMBLY
Install Tires
DRIVE TIRES
Install tires on a hard, level surface as follows:
1. Lift front end of windrower using a forklift and
place 14” (35 cm) blocks under yellow skid
shoes (S) on front frame legs.
2. Install drive tires onto power wheels ensuring
tire tread points forward and air valve stems are
on the outside.
NOTE: For "Turf and Field" tires (diamond or
rectangular tread), be sure arrow on sidewall
points in forward rotation.
3. Torque drive wheel bolts as follows:
9 Bolt Rim: 130 ft. lbs. (175 N⋅m.)
8 Bolt Rim: 180 ft. lbs. (245 N·m)
Follow proper bolt tightening sequence (see
Maintenance/Service section). Re-check torque
as follows:
• Every 15 minutes on the road or 60 minutes in
the field until torque stabilizes, then
• Daily (10 hours) until no change is recorded for
3 consecutive days (30 hours), then
• Every 200 hours or annually thereafter.
4. Lift front end of windrower with forklift and remove the blocks from under skid shoes. Lower the windrower
onto its tires.
5. IMPORTANT: Remove yellow skid shoes (S) from front frame legs.
DRIVE TIRE INFLATION
Check the tire pressures and adjust if necessary.
CAUTION: When inflating tires, use a
clip-on chuck and extension hose long
enough to allow you to stand to one
side and not facing tire.
NOTE: Pressures below are for a fully loaded
header. If hay conditioner is removed, or a bat reel
replaces a pick-up reel, reduce pressures by 2 psi,
(14 kPa).
Drive Tire Inflation Pressures
Header Model Header Size 21.5L - 16.1 14.9 - 24 500 - 70R24 540- 65R24 or 560-65D24
912, 922, 933 All 19 psi (132 kPa) 33 psi (228 kPa) 19 psi (132kPa) 18 psi (125 kPa)
962 All 21 psi (145 kPa) 36 psi (248 kPa) 21 psi (145 kPa) 20 psi (138 kPa)
972 12 - 21 19 psi (132 kPa) 33 psi (228 kPa) 19 psi (132kPa) 18 psi (125 kPa)
972/Sprayer 25 - 36 25 psi (172 kPa) 42 psi (289 kPa) 24 psi (165 kPa) 22 psi (151 kPa)
S
REMOVE
INSTALL DRIVE TIRES & REMOVE SKID SHOES
STAND TO ONE SIDE WHEN INFLATING TIRES
- 9250/9350/9352 1
- SELF-PROPELLED 1
- WINDROWER 1
- Proposition 65 Warning 2
- INTRODUCTION 3
- TABLE OF CONTENTS 4
- SERIAL NUMBER LOCATIONS 7
- SAFETY 10
- SPECIFICATIONS 13
- SPECIFICATIONS 14
- TORQUE SPECIFICATIONS 15
- TORQUE SPECIFICATIONS 16
- OPERATOR'S STATION 17
- Symbol Definitions 17
- OPERATOR'S STATION 19
- Mac-Monitor 19
- Mac-Monitor: 20
- Operator Presence System 21
- Speedometer 21
- Ignition Switch 22
- OPERATOR'S STATION 23
- Cab Temperature Controls 23
- Windshield Wiper Control 23
- Windrower Controls 24
- Header Controls 25
- Header Controls (continued) 26
- Seat Belts 27
- Seat Adjustments 28
- Operator Amenities 29
- OPERATION 30
- To the New Operator 30
- Break-in Period 31
- OPERATION 32
- Pre-Starting Checks: Annual 32
- Pre-Starting Checks: Daily 33
- Start-Up Procedure 34
- Driving the Windrower 36
- Stopping Procedure 40
- Leaving the Windrower 41
- Attaching the Header 42
- (continued) 44
- Adding Rear Weight 45
- Detaching the Header 47
- Header Angle 50
- HEADER TILT HYDRAULIC 50
- ADJUSTMENT 50
- Header Levelling 51
- Header Flotation 52
- Transporting the Windrower 53
- Storage Procedure 58
- Service Procedures 59
- Fuels, Fluids and Lubricants 61
- 50 Hours (continued) 64
- 200 Hours or Annually 65
- Diesel Engine 67
- Diesel Engine (continued) 69
- Diesel Engine: Fuel System 73
- Engine Exhaust System 78
- Engine Cooling System 79
- Electrical System 82
- Hydraulic System 91
- Header Drive: Hydraulics 94
- Traction Drive: Hydraulics 99
- MAINTENANCE/SERVICE 100
- Steering Checks 100
- MAINTENANCE/SERVICE 101
- Steering Checks (continued) 101
- Troubleshooting 103
- Procedure (continued) 105
- Friction Device Adjustment 106
- AT HALF-WEAR STAGE 110
- MAINTENANCE/SERVICE 111
- Traction Drive: Park Brake 111
- Cab Air System 112
- Maintenance Schedule 115
- MAINTENANCE RECORD 117
- (continued) 118
- TROUBLE SHOOTING 119
- Electrical 127
- Traction Drive System 128
- Header Hydraulics 131
- Header Drive 131
- TROUBLE SHOOTING 132
- Header Drive (continued) 133
- Park Brake 133
- Operator's Seat 133
- OPTIONS AND ATTACHMENTS 134
- UNLOADING 135
- Prepare to Unload 135
- Two Forklift Method 135
- UNLOADING 136
- One Forklift Method 136
- ASSEMBLY 137
- Install Tires 137
- ASSEMBLY 140
- Battery 140
- ASSEMBLY 141
- Adjustments and Checks 141
- Cab Heater 141
- Preparing the Tractor for 142
- Preparing 972 Harvest Header 145
- Radio Installation 146
- Two-Way Radio Installation 147
- Tool Box 147
- Swath Roller 148
- INDEX 150
- Self-Propelled Windrower 153
- Pre-Delivery Checklist 153
- Roof Wiring Schematic 155
- Cab Wiring Schematic 156
- Tractor Wiring Schematic 157
Related products and manuals for Gardening equipment Macdon 9250 SP
Gardening equipment Macdon D65 User Manual
(166 pages)
(166 pages)
Gardening equipment Macdon D65 User Manual
(42 pages)
(42 pages)
Gardening equipment Macdon A-30D User Manual
(140 pages)
(140 pages)
Gardening equipment Macdon A40-D User Manual
(193 pages)
(193 pages)
Gardening equipment Macdon 922 User Manual
(84 pages)
(84 pages)
© 2020, manymanuals.com. All rights reserved. | 0.144 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals