MacDon 9352 Operator's Manual Page 112
- Page / 160
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Form # 46584 Issue 11/06 Web Rev_01
110
MAINTENANCE/SERVICE
Cab Air System
WARNING: The air conditioning
system is pressurized. Improper
servicing may cause refrigerant to
penetrate eyes and skin or cause
burns. Special equipment and procedures are
required to service the air conditioning system.
See your Windrower dealer for service.
If an accident involving refrigerant should
occur, see a doctor familiar with this type of
injury immediately.
CAB TEMPERATURE CONTROLS
See "Operator's Station" section for information
regarding the use of the various controls affecting
cab temperature.
AIR CONDITIONING CONDENSER
Clean daily
with compressed air. See "Screens
and Coolers" under cooling system maintenance.
FRESH AIR INTAKE FILTER
Clean daily
as follows:
1. Loosen knob (A) and slide retainer out to
release filter (B) from rear of cab roof.
2. Tap filter gently on a flat surface, dirty side
down. Do not tap on a tire, treads may damage
filter pleats.
3. Direct compressed air (100 psi [700 kPa]
maximum) through filter in opposite direction of
air flow arrows.
4. Wash filter as required:
- Soak 15 minutes in warm water (not over 100°F
[40°C]) with Filter Element Cleaner, (Donaldson
D 1400 or equivalent).
- Rinse thoroughly with clean water, (maximum
pressure 40 psi [275 kPa]).
- Shake excessive water from filter and allow
element to dry. Do not use compressed air to
dry filter; it may rupture the wet element.
Protect element from freezing until dry.
5. Reinstall filter, making sure air flow arrows point
towards cab.
CAUTION: The standard cab air
intake filter is not designed to filter
out harmful chemicals.
Follow the chemical manufacturer's
instructions carefully when operating around
spray areas. For use with the MacDon Sprayer,
a replacement charcoal filter is provided.
NOTE:
1. The refrigerant utilized in this machine is
R134a. Total system refrigerant capacity is 1.36
kg (3 lbs.). The compressor oil is SP-15 PAG.
Total system oil requirement is 240 cc (8.1 U.S.
fl.oz.). This amount of oil is included in a new
compressor.
To prevent premature system failure, do not
use refrigerant R12 and/or its oil. Use of
improper refrigerant or oil voids warranty.
2. Service must be performed by a qualified
R134a technician only.
A
B
CAB FRESH AIR INTAKE FILTER
CLEANING AIR FILTER
- 9250/9350/9352 1
- SELF-PROPELLED 1
- WINDROWER 1
- Proposition 65 Warning 2
- INTRODUCTION 3
- TABLE OF CONTENTS 4
- SERIAL NUMBER LOCATIONS 7
- SAFETY 10
- SPECIFICATIONS 13
- SPECIFICATIONS 14
- TORQUE SPECIFICATIONS 15
- TORQUE SPECIFICATIONS 16
- OPERATOR'S STATION 17
- Symbol Definitions 17
- OPERATOR'S STATION 19
- Mac-Monitor 19
- Mac-Monitor: 20
- Operator Presence System 21
- Speedometer 21
- Ignition Switch 22
- OPERATOR'S STATION 23
- Cab Temperature Controls 23
- Windshield Wiper Control 23
- Windrower Controls 24
- Header Controls 25
- Header Controls (continued) 26
- Seat Belts 27
- Seat Adjustments 28
- Operator Amenities 29
- OPERATION 30
- To the New Operator 30
- Break-in Period 31
- OPERATION 32
- Pre-Starting Checks: Annual 32
- Pre-Starting Checks: Daily 33
- Start-Up Procedure 34
- Driving the Windrower 36
- Stopping Procedure 40
- Leaving the Windrower 41
- Attaching the Header 42
- (continued) 44
- Adding Rear Weight 45
- Detaching the Header 47
- Header Angle 50
- HEADER TILT HYDRAULIC 50
- ADJUSTMENT 50
- Header Levelling 51
- Header Flotation 52
- Transporting the Windrower 53
- Storage Procedure 58
- Service Procedures 59
- Fuels, Fluids and Lubricants 61
- 50 Hours (continued) 64
- 200 Hours or Annually 65
- Diesel Engine 67
- Diesel Engine (continued) 69
- Diesel Engine: Fuel System 73
- Engine Exhaust System 78
- Engine Cooling System 79
- Electrical System 82
- Hydraulic System 91
- Header Drive: Hydraulics 94
- Traction Drive: Hydraulics 99
- MAINTENANCE/SERVICE 100
- Steering Checks 100
- MAINTENANCE/SERVICE 101
- Steering Checks (continued) 101
- Troubleshooting 103
- Procedure (continued) 105
- Friction Device Adjustment 106
- AT HALF-WEAR STAGE 110
- MAINTENANCE/SERVICE 111
- Traction Drive: Park Brake 111
- Cab Air System 112
- Maintenance Schedule 115
- MAINTENANCE RECORD 117
- (continued) 118
- TROUBLE SHOOTING 119
- Electrical 127
- Traction Drive System 128
- Header Hydraulics 131
- Header Drive 131
- TROUBLE SHOOTING 132
- Header Drive (continued) 133
- Park Brake 133
- Operator's Seat 133
- OPTIONS AND ATTACHMENTS 134
- UNLOADING 135
- Prepare to Unload 135
- Two Forklift Method 135
- UNLOADING 136
- One Forklift Method 136
- ASSEMBLY 137
- Install Tires 137
- ASSEMBLY 140
- Battery 140
- ASSEMBLY 141
- Adjustments and Checks 141
- Cab Heater 141
- Preparing the Tractor for 142
- Preparing 972 Harvest Header 145
- Radio Installation 146
- Two-Way Radio Installation 147
- Tool Box 147
- Swath Roller 148
- INDEX 150
- Self-Propelled Windrower 153
- Pre-Delivery Checklist 153
- Roof Wiring Schematic 155
- Cab Wiring Schematic 156
- Tractor Wiring Schematic 157
© 2020, manymanuals.com. All rights reserved. | 0.353 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals